10 Month Maintenance Update

I have been doing six month maintenance updates but I missed updating this when we were in the Marshall Islands.  This blog shows what maintenance we did over the last ten months since the yard visit in Fiji.  Most of the items are the usual preventive and corrective maintenance you expect on a boat in full time use and covering plenty of miles.

Lots of hands now to help with projects.  In this case, changing the engine oil with a drill-driven pump.

The larger projects include:

- New oversized autopilot drive and keeping the old one as a spare.
- New house bank batteries - 940 Amp Hours - we had hoped this could wait until New Zealand but alas they were just not going to make it there.  We had forgotten how nice batteries that hold their charge can be.
- New windlass bank batteries
- New battery charger that accepts power anywhere in the world.  This allows us to plug into shore power for the first time since Mexico and can be powered our new little Yamaha generator.
- Reorganisation of some of the electronics at the chart table now that the antique Trimble mostly died

Here is the dump from the spreadsheet with some of the columns deleted for clarity.  It can be a bit misleading as some of the items are only a few minutes work - takes longer to get the tools out than to do the job - and some took a week to complete.

Date	Maintenance Item	Periodicity	Category
09-Oct-16	check and lubricate steering cable under bunk	3 mon	under bunk
11-Oct-16	fuel line near lift pump – corroded ? - replaced		engine
11-Oct-16	lift pump leak – installed new pump		engine
14-Oct-16	autopilot drive leak		autopilot
14-Oct-16	running light – stern – temp fix		electrical
14-Oct-16	chartplotter will not load -replaced chartplotter		Electronics
14-Oct-16	Autopilot - check bolt torque	3 mon	Lazerrete
14-Oct-16	autopilot brush and hyd fluid check	6 mon	Lazerrete
14-Oct-16	backstay cylinder leaking – repair		Rigging
14-Oct-16	reflective tape – kid harnesses		Safety
14-Oct-16	reflective tape – on anchor roller		Safety
14-Oct-16	reflective tape – outboard		Safety
14-Oct-16	reflective tape – SUP paddle		Safety
14-Oct-16	wind generator – test – smell ?
16-Oct-16	autopilot drive – not driving - reset brushes		Electronics
16-Oct-16	dodger clear – restich
17-Oct-16	engine temp alarm wiring – reconnect		Engine
17-Oct-16	engine water strainer	30 days	Engine
17-Oct-16	Engine zinc	30 days	Engine
17-Oct-16	Oil cooler zinc	30 days	Engine
17-Oct-16	Alternator – check alt 2 temp wiring
19-Oct-16	Alternator – set absorption time to 3 hours
19-Oct-16	Furler – add wraps
19-Oct-16	reset alternator regulator error codes
22-Oct-16	light switch in V berth		electrical
22-Oct-16	Windlass - bimonthly	2 Mon	Grease
22-Oct-16	windlass u/s -sheared roll pin – 4.5 mm diameter		windlass
25-Oct-16	Outboard – replace cotter pin		outboard
26-Oct-16	Autopilot – rudder response failure – reset brushes – slight corrosion on brush spring ?		autopilot
27-Oct-16	Autopilot - check bolt torque	3 mon	autopilot
27-Oct-16	Autopilot – rudder response failure – put in new brushes		autopilot
27-Oct-16	autopilot brush and hyd fluid check	6 mon	autopilot
30-Oct-16	temp repair to outboard over		outboard
30-Oct-16	clean reefer strainer and bowl	2 Mon	reefer
31-Oct-16	tighten valve cover – oil leaking ?		Engine
02-Nov-16	reduced autopilot gain by 0.2
03-Nov-16	check fuel filter bowls	Monthly	Engine
03-Nov-16	restart Iridium Go		IT
03-Nov-16	clean watermaker sea strainer	Monthly	WM
03-Nov-16	clean watermaker sea strainer		WM
03-Nov-16	Watermaker carbon filter	6 mon	WM
03-Nov-16	Watermaker carbon filter	6 mon	WM
03-Nov-16	icebox drain filter	2 Mon
03-Nov-16	vacuum/clean wind gen controller
4-Nov-16	clean watermaker pleated filter	Monthly	WM
4-Nov-16	restart Iridium Extreme
05-Nov-16	alternator x 3 and starter - check wiring	125	engine
05-Nov-16	check alternator belt tension – tightened	25	engine
05-Nov-16	check engine mount nuts	100	engine
05-Nov-16	engine air filter check	125	engine
5-Nov-16	engine water strainer	30 days	Engine
05-Nov-16	top up oil		Engine
5-Nov-16	tighten inner forestay		Rigging
07-Nov-16	mainfurl - Grease the grease nipple on the aft end of the spar.	2 Mon	Grease
7-Nov-16	aft head – leak at pump handle		plumbing
7-Nov-16	aft head overhaul – replaced joker valve ,pump handle axle, pump axle seal, foot pedal seal, top and bottom flapper valves, bowl gasket, one attachment bolt, descaled.	12 mon	plumbing
7-Nov-16	rhib patch – stbd bottom		rhib
07-Nov-16	cotter pin toggles and turnbuckles		Rigging
07-Nov-16	extra wire tie on anchor shackle
07-Nov-16	tighten compass seal
07-Nov-16	top up compass fluid
08-Nov-16	hull/Prop clean	Monthly
8-Nov-16	Prop/shaft zincs	2 mon
08-Nov-16	windgenerator bearings – bearing split – replaced with Air X bearings x 2
10-Nov-16	spinnaker pole attachment – locktite assy, seiqing wire the pin, stikaflex shim to toggle
10-Nov-16	Windlass - electrical tape wiring leads
10-Nov-16	Windlass – replace shear pin
11-Nov-16	mainsail inspection	12 mon	sail
11-Nov-16	Mainsail – sailtape on batten packet
12-Nov-16	barometer calibrate
12-Nov-16	boat speed calibration – 0.95
18-Nov-16	Reefer = turn down settings – fridge frm 27 to 22, freezer -13 to -17		reefer
18-Nov-16	check lines for frayed ends and fix		Rigging
18-Nov-16	fix stbd traveller cam cleat supprt		Rigging
18-Nov-16	fix hole in canvas bucket
18-Nov-16	trim chafe dock lines
18-Nov-16	wind generator vibration
19-Nov-16	Outboard 15hpsparkplugs	6 mon	outboard
19-Nov-16	aft head leak ? - tighten handle and bowl bolts
19-Nov-16	Outboard 15 hp t handle – retie
19-Nov-16	reflective tape – sides of ouboard
19-Nov-16	Whichard chain hook for snubber#2
23-Nov-16	check dive regulator on long hose		dive
23-Nov-16	Fishfinder – run diagnostic		Electronics
23-Nov-16	check alternator belt tension	25	engine
23-Nov-16	check crackcase vent hose for oil leak ?		Engine
23-Nov-16	resew dingy anchor bag		Sewing
23-Nov-16	WM pump /HP hose – chafe spot		watermaker
23-Nov-16	WM pump # 1 tighten fasteners		watermaker
23-Nov-16	bimini - water proofing	6 mon
23-Nov-16	wind angle sensor – disassemble and clean
25-Nov-16	check aft lower deck tie witness marks	3 mon	Rigging
26-Nov-16	fish finder – wiring ?		Electronics
29-Nov-16	check fuel filter bowls	Monthly	Engine
29-Nov-16	Battery water - aft - 60 days	60 days
29-Nov-16	Battery water - start battery - 60 days	120 days
29-Nov-16	corrosion on battery terminals – port aft
30-Nov-16	gaff rope		fishing
30-Nov-16	fix deck wrench
30-Nov-16	new line for liferaft securing line
30-Nov-16	temp repair – cockpit table
1-Dec-16	top up coolant – added 1L distilled water		Engine
4-Dec-16	Fishfinder – clean sensor surface
4-Dec-16	hull/Prop clean	Monthly
4-Dec-16	Prop/shaft zincs	2 mon
06-Dec-16	Outboard 15 hpanode	6 mon	outboard
11-Dec-16	creaking sound from emergency tiller bearing – relubricaed
14-Dec-16	Rhib – lose corner on hull patch
15-Dec-16	toilet valve – leaks		plumbing
16-Dec-16	wind generator vibration
17-Dec-16	test staysail
20-Dec-16	check alternator belt tension	25	engine
20-Dec-16	check engine mount nuts	50	engine
2016-12-20	engine water strainer	30 days	Engine
20-Dec-16	Engine zinc	30 days	Engine
20-Dec-16	Oil cooler zinc	30 days	Engine
20-Dec-16	Steering cable tightness - check quarterly	3 mon	Lazerrete
20-Dec-16	clean reefer strainer and bowl	2 Mon	reefer
20-Dec-16	Stbd 27 winch – raised shaft ?		Rigging
20-Dec-16	clean watermaker pleated filter	Monthly	watermaker
20-Dec-16	clean watermaker sea strainer	Monthly	watermaker
20-Dec-16	Pressure water filter	4 mon
20-Dec-16	rhib fuel tank – leak ?
22-Dec-16	preventor block stbd side aft – replace		Rigging
23-Dec-16	shower drain pump – leak		plumbing
23-Dec-16	preventor block port side aft – low friction ring		Rigging
23-Dec-16	Fishing lines – news smaller lure
23-Dec-16	watermaker overflow – check
29-Dec-16	Squeak in port shrouds - rig inspection, clean fittings, nff		Rigging
02-Jan-17	check alternator belt tension	25	engine
02-Jan-17	Oil (100 hrs) - 7.95L of oil	125	engine
02-Jan-17	Oil Filter Change	250	engine
02-Jan-17	mainfurl - Grease the grease nipple on the aft end of the spar.	2 Mon	Grease
02-Jan-17	Windlass - bimonthly	2 Mon	Grease
02-Jan-17	anchor shackle - check and replace seizing	3 mon
02-Jan-17	Big laptop - new battery and hardrive - bigger
02-Jan-17	big laptop – won't turn on
09-Jan-17	clean watermaker pleated filter	Monthly	watermaker
09-Jan-17	clean watermaker sea strainer	Monthly	watermaker
09-Jan-17	replace broken hose clamp on WM filter
14-Jan-17	clean reefer strainer and bowl	2 Mon	reefer
18-Jan-17	check engine hoses	12 month	engine
18-Jan-17	check windlass oil level	2 Mon	windlass
18-Jan-17	Battery water and clean battery top - aft - 60 days	45 days
18-Jan-17	Battery water and clean battery top- fwd - 60 days	60 days
18-Jan-17	vacuum/clean wind gen controller	2 Mon
19-Jan-17	Autopilot - check bolt torque	3 mon	autopilot
19-Jan-17	autopilot brush and hyd fluid check – 16mm of 18mm brushes, 26 mm of oil	3 mon	autopilot
19-Jan-17	network cb blows – isolated fishfinder from network		electrical
19-Jan-17	exhaust temp alarm – missing bolt		Engine
19-Jan-17	hose clamp on fuel line stbd side of engine room x2		Engine
19-Jan-17	positive post for start alternator – loose		Engine
19-Jan-17	Pelican lights – connection cleaned
19-Jan-17	stern light/trimble ant pole – broken support bolt
20-Jan-17	crack in dingy wheel axle		dingy
20-Jan-17	MOB light - new D cell x 5	12 mon	MOB
20-Jan-17	rebed hole outboard of stbd saloon hatch		rebed
20-Jan-17	dorade vent hose above chart table
20-Jan-17	Micronesia charts on Garmin GPS
23-Jan-17	Nav laptop -bluetooth		IT
23-Jan-17	update PW Offshore		IT
23-Jan-17	update sailmail		IT
23-Jan-17	replace anchor shackle
25-Jan-17	engine room light		electrical
25-Jan-17	Fishfinder – blows fuse – replaced power lead with Furuno power lead		electrical
25-Jan-17	rebed fishfinder/speaker wire – leaking into galley		rebed
25-Jan-17	redo deckhead fastener holes – galley		rebed
25-Jan-17	redo deckhead fastener holes – saloon lazerette access		rebed
25-Jan-17	new chain hooks for snubbers		Rigging
26-Jan-17	redo deckhead fastener holes – chart table		rebed
26-Jan-17	redo deckhead fastener holes – saloon		rebed
26-Jan-17	Replace floating tow line for rhib		Rigging
26-Jan-17	dodger clears clean
26-Jan-17	reflective/insulating layer for v-berth
26-Jan-17	Replacement barometer
26-Jan-17	soap container for galley
27-Jan-17	caulking replacement in aft head		caulking
27-Jan-17	Program SSB for Yokwe net
27-Jan-17	reflective/insulating layer for fwd head
28-Jan-17	check fuel filter bowls	Monthly	Engine
28-Jan-17	icebox drain filter	3 mon	plumbing
28-Jan-17	pole topping lift chafe – replace add dynmea chafe protection		Rigging
28-Jan-17	clean watermaker pleated filter	Monthly	watermaker
28-Jan-17	clean watermaker sea strainer	Monthly	watermaker
28-Jan-17	defrost and clean fridge
28-Jan-17	extra insulation for fridge top
28-Jan-17	replace rubber mounts for life raft
30-Jan-17	chart table fan – new plug		electrical
30-Jan-17	fix headlamp		electrical
30-Jan-17	fuel manifold/watermaker cabinet light		electrical
30-Jan-17	adjust aft fuel tank sensors
30-Jan-17	hole below engine inst panel
31-Jan-17	EPIRB Battery – relegated to back up		Safety
1-Feb-17	hull/Prop clean	Monthly
1-Feb-17	Prop/shaft zincs	2 mon
1-Feb-17	replace toilet seat
09-Feb-17	dryout v berth
10-Feb-17	teak caulking by boarding entrance		teak
10-Feb-17	adjust wind gen blades
12-Feb-17	tighten inner forestay		Rigging
12-Feb-17	tighten lower shrouds – two turns on fwd lower and one turn on aft lower		Rigging
15-Feb-17	rubber feet for midship swim ladder
17-Feb-17	reset FB/Go		IT
17-Feb-17	Rhib – leak between tube and hull		rhib
17-Feb-17	mount old EPIRB		Safety
17-Feb-17	register EPIRB		Safety
20-Feb-17	clean corrosion on fishfinder plug ?		Electronics
20-Feb-17	add wraps to genoa furler		Rigging
20-Feb-17	check aft lower deck tie witness marks	3 mon	Rigging
08-Mar-17	alternator x 3 and starter - check wiring	125	engine
08-Mar-17	alternator x 3 and starter - check wiring	125	engine
08-Mar-17	check alternator belt tension	25	engine
08-Mar-17	check engine mount nuts	50	engine
08-Mar-17	check fuel filter bowls	Monthly	Engine
08-Mar-17	engine water strainer	30 days	Engine
08-Mar-17	Engine zinc	30 days	Engine
08-Mar-17	Oil cooler zinc	30 days	Engine
08-Mar-17	resecure engine temp alarm wiring		Engine
08-Mar-17	clean reefer strainer and bowl	2 Mon	reefer
08-Mar-17	investigate corrosion stain on stbd cap shroud – clean chain plate		Rigging
08-Mar-17	tighten cap shroud one turn		Rigging
08-Mar-17	cotter pins on cap shroud turnbuckles
10-Mar-17	propane locker repair
13-Mar-17	replace fish hooks plus small lure		fishing
15-Mar-17	zincs for dingy ?
16-Mar-17	port side fan – aft bunk		electrical
16-Mar-17	Battery water and clean battery top - aft - 60 days	45 days
16-Mar-17	vacuum/clean wind gen controller	2 Mon
18-Mar-17	rescue tape on chartplotter connections
27-Mar-17	rhib seat bag zipper		Sewing
02-Apr-17	check fuel filter bowls	Monthly	Engine
10-Apr-17	Fan – port side aft cabin		electrical
10-Apr-17	check leak port aft lower cap shroud		rebed
10-Apr-17	port main winch – electric engage		winch
10-Apr-17	electrical tape over chartplotter connections
10-Apr-17	polish rigging stainless
11-Apr-17	rebed HF wire		rebed
11-Apr-17	fix shower teak grate
12-Apr-17	Inspect lifelines	12 month	rigging
13-Apr-17	Engine coolant change 13L	12 mon	Engine
13-Apr-17	exhaust elbow - inspect	24 month	Engine
13-Apr-17	Impeller speedseal disc replacement Nov 14	2 years	engine
13-Apr-17	Honda Generator - spark plug CR5HSB NGK	12 mon	Generator
13-Apr-17	mainfurl - Grease the grease nipple on the aft end of the spar.	2 Mon	Grease
13-Apr-17	Windlass - bimonthly	2 Mon	Grease
13-Apr-17	Windlass Service - preseason service - every 6 mon	6 mon	Grease
13-Apr-17	Outboard 15 hp grease plus corrosion spray on throttle cables	3 mon	outboard
13-Apr-17	Outboard 15 hpfuel filter	6 mon	outboard
13-Apr-17	Outboard 15hpsparkplugs	6 mon	outboard
13-Apr-17	confirm emergency numbers in Satphone	12 mon	Safety
13-Apr-17	replace bolt on aft lower chain plate
14-Apr-17	clean engine pan		Engine
14-Apr-17	Transmission oil change (every 400 hrs or annually) 2.36L	400	engine
14-Apr-17	Pressure water filter	4 mon	plumbing
14-Apr-17	anchor shackle - check and replace seizing	3 mon	Rigging
14-Apr-17	Gooseneck – replace nylon washer		Rigging
14-Apr-17	paint anchor tip
15-Apr-17	Honda generator - oil change	12 mon	Generator
15-Apr-17	Overhaul winch - Anderson	12 mon	winch
15-Apr-17	Overhaul winch - port 28	12 mon	winch
16-Apr-17	Impeller replacement	250	engine
17-Apr-17	check alternator regulator temp connections		Engine
18-Apr-17	Outboard 15 hp gear oil	6 mon	outboard
18-Apr-17	Outboard 15 hp grease prop shaft	6 mon	outboard
18-Apr-17	outboard propeller replacement		outboard
18-Apr-17	Rigging check up mast
19-Apr-17	portable watermaker – annual maintenance	12 mon	Safety
20-Apr-17	anchor light/strobe light u/s		electrical
20-Apr-17	Review Ditch Bag contents	12 mon	Safety
21-Apr-17	Battery water and clean battery top- fwd - 60 days	60 days	battery water
21-Apr-17	Replacement antenna for portable VHF		Electronics
21-Apr-17	adjust custom alternator regulator settings – Vabsorb 14.6, ffl 25, Absorb time 60, Max Alt Temp 95, Max Batt Temp 43,		Engine
21-Apr-17	check windlass oil level	2 Mon	windlass
21-Apr-17	OPENCpn chart update
22-Apr-17	clean bilge – add cleaner		bilge
22-Apr-17	small bilge pump strum box		bilge
22-Apr-17	Fan – v berth		electrical
22-Apr-17	Fans – saloon		electrical
22-Apr-17	Ditch bag – add C cells and check for VHF battery pack		Safety
22-Apr-17	ditch bag – add electric flare		Safety
24-Apr-17	Lubricate and inspect steering chain	6 mon	binnacle
24-Apr-17	top up compass		binnacle
24-Apr-17	paint mushroom anchor
25-Apr-17	leak around oil filler cap ?		Engine
25-Apr-17	Add spinlock “lume” lights to PFDx2		Safety
25-Apr-17	replace CO2 – Liz PFD		Safety
25-Apr-17	straps for jerry cans		Sewing
27-Apr-17	Alternator sensors erratic		electrical
27-Apr-17	Install spare starter motor		Engine
27-Apr-17	check cap shroud bolt tension		Rigging
27-Apr-17	PFD – manual inflation and inspect	6 mon	Safety
28-Apr-17	replace dingy anchor chain		dingy
28-Apr-17	repair kite pump hose		kite
01-May-17	Replace windlass bank – Windlass bank low V – 10” by 14” 95 reserve minutes – 11.6v on one, 12.5 on other		electrical
02-May-17	Add wraps to mainfurl line		Rigging
02-May-17	Port 36 winch – electric engage popped.		winch
4-May-17	Autopilot - check bolt torque	3 mon	autopilot
4-May-17	autopilot brush and hyd fluid check – 16 and 15 mm of brushes, 23 mm of fluid	3 mon	autopilot
4-May-17	check and lubricate steering cable	6 mon	Lazerrete
4-May-17	Grease rudder reference bearing	12 mon	Lazerrete
4-May-17	Steering cable tightness - check quarterly	3 mon	Lazerrete
05-May-17	Battery water - start battery - 60 days	120 days	battery water
05-May-17	Battery water and clean battery top - aft - 60 days	45 days	battery water
05-May-17	Dingy drain plug – replace		dingy
05-May-17	install water towed generator		electrical
05-May-17	check fuel filter bowls	Monthly	Engine
05-May-17	engine water strainer	60 days	Engine
05-May-17	Engine zinc	60 days	Engine
05-May-17	Oil cooler zinc	60 days	Engine
05-May-17	clean reefer strainer and bowl	2 Mon	reefer
05-May-17	clean stbd spin halyard rope clutch		Rigging
7-May-17	new galley fan		electrical
7-May-17	MOB light – check connection		Safety
7-May-17	patch Max pfd cover		Safety
7-May-17	amend target speeds on chartplotter
7-May-17	defrost reefer
7-May-17	Dodger clean
7-May-17	renew galley bungy
9-May-17	watertight fittings for water towed generator		electrical
9-May-17	check starter motor torque in 5 hours
9-May-17	UV screen on v berth hatch
10-May-17	check storm staysail and trysail	12 mon	sail
10-May-17	restich front of dodger		Sewing
10-May-17	clean watermaker pleated filter	2 Mon	watermaker
10-May-17	clean watermaker sea strainer	2 Mon	watermaker
10-May-17	hull/Prop clean	2 Mon
10-May-17	Prop/shaft zincs	2 mon
12-May-17	alternator regulator – temp sensor connections
22-May-17	Honda generator – will not start		Generator
24-May-17	Change reefer thermostat (last change was fridge frm 22 to 27, freezer -17 to -13)		reefer
26-May-17	Resecure watermaker membrane		watermaker
27-May-17	check fuel filter bowls	Monthly	Engine
28-May-17	reefer overpressure – cleaned sea strainer		reefer
29-May-17	pressure water leak		plumbing
29-May-17	Prop/shaft zincs	2 mon
29-May-17	vacuum/clean wind gen controller	2 Mon
30-May-17	battery bank – determine if bad battery		electrical
31-May-17	battery bank – isolate bad battery		electrical
03-Jun-17	Outboard 15 hpanode	6 mon	outboard
04-Jun-17	all VHF to International mode		Electronics
04-Jun-17	Inverter not starting
08-Jun-17	windlass bank fuse blown – new fuse and fixed wiring on energy montor		electrical
09-Jun-17	new lanyard for windlass lever
14-Jun-17	added engine coolant		Engine
16-Jun-17	check engine coolant – topped up		Engine
17-Jun-17	exhaust elbow leak – temp repair		Engine
17-Jun-17	Oil (100 hrs) - 7.95L of oil	125	engine
17-Jun-17	mainfurl - Grease the grease nipple on the aft end of the spar.	2 Mon	Grease
17-Jun-17	Windlass - bimonthly	2 Mon	Grease
17-Jun-17	Watermaker carbon filter	6 mon	WM
17-Jun-17	replace lanyard for inner forestay clevis pin
19-Jun-17	check hull damage stbd fwd
20-Jun-17	hull/Prop clean	Monthly
20-Jun-17	Prop/shaft zincs	2 mon
22-Jun-17	engine will not start – replaced auxiliary solenoid		Engine
24-Jun-17	patch exhaust elbow		Engine
24-Jun-17	Generator starts but will not produce AC power – cleaned wiring plugs and stator, cleaned carb		Generator
24-Jun-17	Honda generator - Clean air filter	12 mon	Generator
24-Jun-17	Honda Generator - Fuel Filter	12 mon	Generator
25-Jun-17	patch exhaust elbow v 3		Engine
25-Jun-17	Honda generator - Clean air filter	12 mon	Generator
25-Jun-17	Honda Generator - Fuel Filter	12 mon	Generator
27-Jun-17	Battery water and clean battery top - aft - 60 days	45 days	battery water
27-Jun-17	tricolour intermittent		electrical
05-Jul-17	check alternator belt tension	50	engine
05-Jul-17	check fuel filter bowls	Monthly	Engine
05-Jul-17	clean out end of heat exchanger		Engine
05-Jul-17	engine water strainer	60 days	Engine
05-Jul-17	Engine zinc	60 days	Engine
05-Jul-17	Oil cooler zinc	60 days	Engine
05-Jul-17	clean watermaker pleated filter	2 Mon	watermaker
05-Jul-17	clean watermaker sea strainer	2 Mon	watermaker
06-Jul-17	fuel line bracket – tighten		Engine
06-Jul-17	resecure exhaust temp sensor		Engine
06-Jul-17	temp repair to oil pressure sensor tube		Engine
06-Jul-17	tighten crankcase vent piping ?		Engine
06-Jul-17	galley leak		plumbing
06-Jul-17	clean reefer strainer and bowl	2 Mon	reefer
10-Jul-17	port side saloon fan not working		electrical
10-Jul-17	check aft lower deck tie witness marks	6 mon	Rigging
10-Jul-17	check windlass oil level	3 mon	windlass
11-Jul-17	Rebed – deck drain behind VHF		rebed
11-Jul-17	Rebed – Stbd aft saloon window		rebed
11-Jul-17	Rebed – window above chart tabel		rebed
11-Jul-17	rebed bolts on dodger infill track		rebed
11-Jul-17	anchor shackle - check and replace seizing	3 mon	Rigging
11-Jul-17	replace anchor roller restraining line		Rigging
11-Jul-17	Rebed - toerail near VHF
11-Jul-17	Rebed – drain hose from wiring condui
12-Jul-17	exhaust elbow patch v4		Engine
12-Jul-17	valve cover gasket leaking ?		Engine
12-Jul-17	epoxy hull ding forward sbd		Hull
12-Jul-17	Steering cable tightness - check quarterly	3 mon	Lazerrete
12-Jul-17	backup backstay with amsteel		Rigging
12-Jul-17	dowling on back stay cylinder		Rigging
12-Jul-17	WM leak		wM
13-Jul-17	portable fan wiring		electrical
13-Jul-17	new gasket for saloon window stbd aft		rebed
13-Jul-17	Clean/santizie water jerry cans	6 mon
14-Jul-17	add fuse between echo charger and battery monitor		electrical
14-Jul-17	crimp on water towed generator		electrical
14-Jul-17	fish light		electrical
14-Jul-17	mount portable VHF chargers		Electronics
14-Jul-17	Replace Trimble GPS with Furuno GPS		Electronics
15-Jul-17	test leads with 12V plug		electrical
15-Jul-17	plug hole in pushpit stanchion		rebed
15-Jul-17	Rebed – stbd deck box		rebed
15-Jul-17	rebed backstay		rebed
15-Jul-17	rebed HF antenna		rebed
15-Jul-17	rebed stern light wire		rebed
16-Jul-17	Rebed – port aft lower shroud		rebed
16-Jul-17	Rebed – Stbd cap shroud		rebed
16-Jul-17	Rebed – stbdt aft lower shroud		rebed
16-Jul-17	rebed port cap shroud chain plate		rebed
17-Jul-17	purge dockboxes		organise
17-Jul-17	Port dock box rebed		rebed
17-Jul-17	replace stbd dock box inboard fwd bolt		rebed
20-Jul-17	reattach autopilot solenoid testing cct		lazerrete
21-Jul-17	epoxy rot beside stbd chainplate		Rigging
24-Jul-17	repair rot in stbd dock box – Git rot and the epoxy filler
25-Jul-17	rebed traveller bolts – from port bolts 3,4 and centre		rebed
27-Jul-17	free up zinc caps for heat exchangers		Engine
27-Jul-17	replace corroded preventer thimble		Rigging
28-Jul-17	touch up engine paint		Engine
30-Jul-17	vacuum/clean wind gen controller	2 Mon
31-Jul-17	new autopilot drive		autopilot
31-Jul-17	return HX851 VHF for repair		Electronics
31-Jul-17	rudder stops – check and replace rubber	12 mon	lazerrete
31-Jul-17	Grease autopilot rod end bearing	6 mon
01-Aug-17	aft cabin fan wiring		electrical
01-Aug-17	Grease water towed generator gimbals		Grease
02-Aug-17	Stove – sparker – replace battery holder		electrical
02-Aug-17	replace generator carburetor		Generator
02-Aug-17	replace generator ignition control module		Generator
02-Aug-17	mainfurl - Grease the grease nipple on the aft end of the spar.	2 Mon	Grease
02-Aug-17	Windlass - bimonthly	2 Mon	Grease
02-Aug-17	Outboard 15 hp grease plus corrosion spray on throttle cables	3 mon	outboard
02-Aug-17	icebox drain filter	3 mon	plumbing
05-Aug-17	check fuel filter bowls	Monthly	Engine
05-Aug-17	adjust generator valves – reduced gap.		Generator
05-Aug-17	bimini - water proofing	6 mon
06-Aug-17	Overhaul winch - port 36	12 mon	winch
06-Aug-17	Overhaul winch - stbd 36	12 mon	winch
07-Aug-17	clean reefer condenser	12 mon	reefer
07-Aug-17	clean bilge
08-Aug-17	Autopilot – autotune		autopilot
08-Aug-17	autopilot hyd fluid reservoir bracket move		autopilot
08-Aug-17	Fuel Filter - Primary	500	engine
08-Aug-17	Fuel Filter - Secondary	500	engine
08-Aug-17	Fuel Filter - Secondary	500	engine
14-Aug-17	Install 240V battery charger		electrical
14-Aug-17	replace PFD CO2 – both		Safety
14-Aug-17	replace strobes in PFD's x 2		Safety
15-Aug-17	Pelican light – replace lamp assy 2004 for Pelican 2000
15-Aug-17	rubber feet for aft swim ladder
15-Aug-17	rubber feet for side ladder
16-Aug-17	replace battery bank		electrical
17-Aug-17	adjust 220V battery charger to 14.8V		electrical
17-Aug-17	adjust solar charge controller to 14.8V		electrical
17-Aug-17	adjust wind gen charge controller to 14.8V		electrical
17-Aug-17	update battery monitor for new batteries		electrical
19-Aug-17	clean water tanks	12 mon	plumbing
19-Aug-17	hull/Prop clean	Monthly
19-Aug-17	Prop/shaft zincs	2 mon
20-Aug-17	top up engine oil		Engine
20-Aug-17	resecure aft battery bank